Alpen Steel | Renewable Energy

~ The Standard Battery Bank On The Airstream

Our Portable Battery Bank.

The standard battery bank on the Airstream consists of two 12-volt group 24 batteries connected in parallel stored just in front of the trailer and behind the propane tanks. Group 24 batteries are designed to hold around 75 amp hours of power each. At a full charge, they store just enough juice for you to run all the lights in the Airstream for about 2 seconds. OK, maybe that is a slight exaggeration, but the power-hungry halogen bulbs Jackson Center, Ohio installed into our 25 foot International are not really designed with boondockers in mind. Bright and warm as they might be, they are very inefficient. Many people have swapped them out for expensive LED versions of these lights bought from Internet sources. The problem with this ‘upgrade’ is that in return of them running forever, you have to deal with these dim little blue lights that makes you feel like you are living in the International Space Station.


Solar panels and generators are great for creating portable power but you need more batteries to hold all those amps generated for when they are not pumping the voltage into our beloved puck lights. That’s especially true for solar panels since they obviously only work when there is day light. Our 25 ft Airstream International FB (Front Bedroom) model gives us the aftermarket option to store some additional batteries in the storage space under the bed. To store deep cycle batteries inside the living space of the trailer means they have to be maintenance-free, sealed versions of these batteries that can sometimes cost twice as much.

As we get closer and closer to hitting the road full time, we are trying to be very careful with budgeting our traveling funds. That means we have to make use with what we already have versus buying more gear unless its absolutely necessary. In my old days as a sailboat owner, I gathered a lot of sailboat cruising related gear. After selling the boat to make room for the Airstream, I kept a couple of lightly-used deep cycle batteries thinking that they might come in handy one day. Unfortunately they were not the sealed versions so they will not be going inside and under the bed.

Battery Bank in a Cooler

After some measuring and scrounging in the garage, I came up with an old Igloo cooler that fits these 2 batteries perfectly. With a few holes drilled for ventilation, the batteries dropped in and were wired up in parallel with some 10-gauge wires.

Battery Bank in a Cooler

The weight of the batteries make the cooler a chore to carry but the handles on the side work well to bear the load with 2 people. A 7-amp solar charge controller connected to the system allows me to maintain these batteries with a small solar cell to keep them topped off in between trips.

Battery Bank in a Cooler

A little terminal block with dual bus plates is used to connect everything to a heavy duty marine battery switch by Perko. The 4-position switch gives me the option to use 1, 2, both or none of the batteries as needed.

You might be wondering now how this homemade contraption allows me to run any of the electrical systems in the Airstream. If you own a travel trailer with a 7-pin hitch connector, you know that the car sends a 12-volt charge to the trailer’s batteries through one of the pins in the connector. The diagram below shows you what each one of those 7 pins do.


By connecting the 12-volt pin and the ground pin to the matching position in a female plug purchased from a trailer store, I mounted them on the outside of the cooler. By simply plugging the trailer into the box, I am now able use the electricity stored in this magical Igloo cooler. What’s even cooler is that it will even charge these batteries the same way when I have a 30-amp power hookup or by running our new-to-us Honda EU2000i generator. In one of the little holes I drilled out in the front of the cooler, I placed a cigarette lighter adaptor that will also allow me to use the power output for things like a 12-volt air compressor while airing up the tires or running a laptop through a small inverter while sitting at the picnic table.

Battery Bank in a Cooler

We have yet to try this setup with the Airstream but it should come in handy at a dry campground to help run that power hungry furnace fan at night when we are not allowed to run the generator. If you decide to build one of these for yourself, be sure to get the heaviest gauge wires you can get your hands on and be very careful not to draw too much load through the trailer harness. Refer to other electrical experts other than just what you see here. You wouldn’t want an electrical fire on your hands. I would keep the extinguisher near just in case.

over and out,

SHARETHIS.addEntry({ title: "Our Portable Battery Bank.", url: "" });ShareThis

Tags: , ,

The Never Ending Debate: Generator vs. Solar Panels. »

by dan on 
  Anda belum mendaftar atau login.
Anda dapat turut serta menuliskan artikel disini, caranya klik disini
Ada pertanyaan? Ingin berdiskusi? silahkan tulis di Alpensteel Forum

Fast Contact

Show Room & Factory:
Jalan Laksanama
Nurtanio Nomor 51
Bandung 40183 - Indonesia
Phone Line1:
022- 603-8050 (08:00-17:00)
PageRank  Hit Counters
free counters
Alpen Steel Facebook